This study experimentally investigates the control system and the algorithm after constructing a HCCI combustion control system for the development of a small HCCI engine fuelled with Dimethyl Ether (DME). This system can control four throttles for the mixing ratio of three gases of in-cylinder (stoichiometric pre-mixture, hot EGR gas and cold EGR gas). At first, the combustion behavior for combustion phasing retarded operation with cold and hot EGR was examined. Then, the potential of model-based and feed back control for HCCI combustion with change of the demand of IMEP was investigated. In the end, the limit of combustion-phasing retard for IMEP and PRR was explored. Results shows that to get high IMEP with acceptable PRR and low coefficient of variation of IMEP, crank angle of 50% heat release (CA50) should be controlled at constant phasing in the expansion stroke. CA50 can be controlled by changing the ratio of pre-mixture, hot EGR gas and cold EGR gas with throttles. Due to the cycle-to-cycle variation, the change of total mass of fuel in cylinder has a big effect on IMEP. After misfire, unburned fuel and intermediates remain in exhaust gas, which is re-breathed as hot EGR gas, and unburned fuel and intermediates are supplied to next cycle. This leads to the total mass of fuel changes cycle-to-cycle. As a result of feedback control, transient performance is realized but high sensitivity of response cannot be achieved under the constant engine speed.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Closed-Loop Combustion Control of a HCCI Engine with Re-Breathing EGR System


    Beteiligte:

    Erschienen in:

    Erscheinungsdatum :

    2013


    Format / Umfang :

    12 pages




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch



    Closed loop combustion control for HCCI

    Grebe,U.D. / Alt,M. / Dulzo,J. et al. | Kraftfahrwesen | 2008


    Closed loop combustion control for HCCI

    Grebe, Uwe Dieter / Alt, Matthias / Chang, Man-Feng | Tema Archiv | 2008


    Closed-Loop Control of an HCCI Engine

    Johansson, Bengt / Olsson, Jan-Ola / Tunestål, Per | SAE Technical Papers | 2001


    Closed-loop control of an HCCI engine

    Olsson,J.O. / Tunestal,P. / Johansson,B. et al. | Kraftfahrwesen | 2001


    HCCI Closed-Loop Combustion Control Using Fast Thermal Management

    Haraldsson, G. / Tunestal, P. / Johanssen, B. et al. | British Library Conference Proceedings | 2004